VW Beetle Window Regulator Repair Guide

Whether you have power or manual windows, the window regulator in your VW Beetle is important. The regulator is the component used to roll your windows up and down — there is a regulator for each window. The power windows on the newer Beetles and the convertibles are designed to drop a fraction when the door is open or the top is closing, and then slide back up when the door is closed. When your regulator isn’t doing its job, it can be puzzling and frustrating, here’s a guide to diagnosis and repair.

Issue: The window makes a grinding sound when I roll it up or down.

What to do:

This is not due to the regulator, but the cable that is part of the window system may be broken.

  1. Take the door apart and check the cable
  2. Replace the cable if needed

Issue: My power window rolls up about halfway, and then it drops back down. Or it will roll half way up and stop.

What to do:

There is a good chance that the regulator in the window is failing.

  1. Disconnect the battery before you start
  2. Remove the door panel
  3. You will need to remove the lock assembly before you can remove the window
  4. Lift the window out and set it aside
  5. The regulator is located in the center of the door
  6. Unplug it from its wiring harness and remove it
  7. Replace the regulator and plug it back into the wiring harness
  8. Reassemble the window, the lock assembly and the door
  9. Reconnect the battery cables

Issue: My rear power window drops when I put the convertible top up, but it does not return to the top or it drops into the door.

What to do:

The power window regulator may be failing.

  • Refer to the regulator installation above.

Issue: My power windows will not work at all.

What to do:

  1. The power windows run on a fuse. If none of your power windows are working, you may need to change the fuse
  2. Check the fuse block under the hood of your VW
  3. Install a new fuse if needed

Issue: My manual windows crank hard, and they stick.

What to do:

Your regulator or the channels in the window may be clogged

  1. Remove the door panel and take the regulator and channels out for cleaning
  2. The slider can be completely removed from the channel
  3. Use a Q-tip and brake cleaner to clean the channels
  4. The channel and the slider can be greased with white lithium grease
  5. Grease other sticky parts and repair old foam or rubber while you have the door apart
  6. Reassemble the door

These are the most common reasons the windows may not be working in your VW Beetle. If you need to replace the window regulator, you may need to do a little work, but the replacement itself is not hard.

Article précédent Article suivant

0 commentaires